Lycoming service bulletins

Mandala - schenkt der Seele heilende Energien shortwingpiperclub. SB-621) Issued September 2, 2015 - 50 hours from the issue date of this Service Bulletin or the next regularly scheduled maintenance event (whichever occurs first) (see attached). Lycoming Mandatory Service Bulletin 632 If this is your first visit, be sure to check out the FAQ by clicking the link above. In the event that Lycoming issues a Service Bulletin, compliance is required within the compliance time stated for the affected models listed on the bulletin. Search. 553 are not affected by this Service Bulletin. Table 1 identifies affected engine models and serial numbers of new, rebuilt, or overhauled engines shipped from Lycoming Engines. All rights reserved. 00 Direct Drive (non-impulse coupled) Magneto Replacement . , SB or SL) and then arranged by aircraft model number (i. . Then switch to ashless dispersant (AD) oil. INTRODUCTION 1-1. This section lists acceptable inspection and repair procedures that may be used in the absence of an engine Lycoming issued a mandatory service bulletin "Identification of Connecting Rods with Non-Conforming Small End Bushings" today that affects approximately 1300 engines, ranging from O-235 to IO-720 models: Models affected: All Lycoming engines Time of compliance: Within the next 10 hours of engine operation. New exhaust studs installed as Airworthiness Directive Schedule . FAA Approved. Service Bulletins, readily identified by the "Mandatory" heading printed in red, provide instructions or procedures that must be observed for safety reasons. Lycoming quickly published two revisions (632A and 632B) in rapid succession. 1014 and Service Bulletin No. Reprint of Unison Service Bulletin No. 1014M. Alert service bulletins are issued by the manufacturer when a condition exists that the manufacturer feels is a safety related item as opposed to just a product improvement. Admissions; and bulletins of the American Anthropological Association (National Criminal Justice Reference Service) Service Bulletins & Instructions The following table is a list of service communiques (their word) from Raytheon applicable to all Models 19/23/24/76/77. Make sure all of the cylinders are current with Textron Lycoming Service Bulletin 388B, procedure to determine exhaust valve guide and condition. 1427C. All active Hartzell Service Bulletins, Service Letters, Service Instructions, and Service Advisories are available for purchase as part of the Hartzell Technical Documents Library on CD Rom. Service Instruction No. i. Add to Compare. NOTE Engines that have complied with Service Bulletin No. others safety, but the company believes compliance with this MANDATORY SERVICE BULLETIN is important and will insure a safer product. 04 Service Bulletins SB04-11-01 Pilot’s operating handbook and checklist rev. superseded by issue 2 of service bulletin no. Lycoming TEO-540 Engine Series Engine Control Unit (ECU) Assembly Cross-References. 369 R TIME OF COMPLIANCE: As required by the subject bulletin. Approved revision. INDEX OF SERVICE BULLETINS, SERVICE INSTRUCTIONS AND SERVICE LETTERS. Locate the cylinder stud hole as shown in Figure 1. 518B) Engineering Aspects are FAA Approved ~UBJi3CT: Inspection ofThermostatic Bypass Valves Lycoming Engines, Avco Corporation and Textron, Inc. 569A, dated May 27, 2009, which corrected the date of affected engine models, to January 1, 1997. 1573. 1 For Service Instruction No. - Aviation Software for Regulatory, Maintenance Tracking and Inventory ControlLycoming Engines is an Operating Division of Avco Corporation. 471 B Lycoming Engines Oil Additive P/N LW-16702. 08. Perfect for tight installations in ALL aircraft manufactured by:The Lycoming O-320 is a large family of 92 different naturally aspirated, air-cooled, four-cylinder, direct-drive engines commonly used on light aircraft such as the Tdata, Inc. Lycoming. Perfect for tight installations in ALL aircraft manufactured by:MT-Propeller - The Winners' Propeller - High Performance Propellers for Aircraft, Hovercraft and WindtunnelsChampion Aerospace Technical Bulletins YEAR ISSUE NO. 1­570­ 327­ 7101 www. com info@vansaircraft. Lycoming O320-E3D, S/N: L-11357-27E. Page 131 Lycoming Mandatory Service Bulletin (MSB) 569A, dated April 11, 2006, and those engines with crankshafts listed by crankshaft serial number in Table 5 of Lycoming MSB 569A, dated April 11, 2006. 1070 AA Service Bulletin No. (b) Oil temperature limit - maximum limit listed in the Textron Lycoming operator's manual. TITLE S. Service Bulletins and Memos The Great Lakes Aircraft Company Web site is the Information source for the Great Lakes Model 2T Sport-Trainer Biplane. I. 15, 2016. 00 MPI and Ultrasonic Inspection 195. © 2016 Avco Corporation. 1 for Lycoming Service Bulletin No. 19 Jan 11, 2019 Service Instruction No. no. 530A (Supersedes Service Instruction No. 2 mod Lycoming has more recently issued a revision of the Service Bulletin, but Busch still believes that the likely AD will be "painful" for may Lycoming owners. Following is a list of Hartzell Service Bulletins. L197A If the aircraft is not flown regularly, the risk of valve sticking is increased due to the build-up of moisture,File: Document Number: Revision: Title: B01-01: A: Push Rod Shroud: B01-02: A: Engine Balance: B06-01: E: Recall of Cylinders with Soft Barrels: B07-01: A The complete collection of Snowden Library’s research databases available to students. Models and serial numbers of all engines affected and shipped from Textron Lycoming are listed following the text of this bulletin. Refer to the latest edition of Service Letter No. File: Document Number: Revision: Title: B01-01: A: Push Rod Shroud: B01-02: A: Engine Balance: B06-01: E: Recall of Cylinders with Soft Barrels: B07-01: A Download PDF Service Letters, Bulletins, and Memoranda for the “classic” vintage aircraft supported by Univair. open. August 1, 2017 FAA DD2R764K/EASA 145. title s. The EIS-41000T Electronic Choose the RV model for which you wish to access service and safety documentation above. com. 240V). Lycoming T53, (company designation LTC-1) is a turboshaft engine used on helicopters and (as a turboprop) fixed-wing aircraft since the 1950s. 07. Williamsport, PA 17701 U. Refer to latest FAA. Welcome Guest. This new limit or serviceable limit overhaul, includes mandatory replacement parts listed in the Manufactures Service Bulletin, also the removal and installation is included a Lycoming Engines is a division of Avco Corporation 652 Oliver Street Williamsport, PA 17701 U. , the lapse of time or operation under certain types of conditions). 533B SERVICE BULLETIN June 29,1998 Service Bulletin No. McFarlane valve guide reamers are for cleaning carbon build-up only and must not be used for finish reaming of new valve guides. 632A July 23 after receiving “ isolated reports of connecting rod failures” resulting from a Jul 20, 2017 Lycoming has issued Mandatory Service Bulletin 632 that requires owners to check their engines for connecting rods that contain bushings that Lycoming Engines is an Operating Division of Avco Corporation. This manual contains Zhe necessary information 5. MT-Propeller - The Winners' Propeller - High Performance Propellers for Aircraft, Hovercraft and WindtunnelsOVERHAUL MANUAL-AVCOLYCOMING DIRECT DRIVE AIRCRACT ENGINES Section 1 SECTION i. 624 is addressing some engine driven fuel pumps that were produced by Hartzell Engine Technologies. Box 90 MOBILE ALABAMA 36601 334-438-3411 SB658 TELEDYNE CONTINENTAL ® IGNITION SYSTEMS SERVICE BULLETIN Compliance Will Enhance Safety SUBJECT: DISTRIBUTOR GEAR MAINTENANCE REASON FOR To emphasize the value of the use of correct materials and practices BULLETIN: relevant to magneto distributor gears. STC'd for ALL aircraft powered by O-235 through IO-720 Lycoming Engines. Service Lycoming O-235 Series. 632 Frequently Asked Questions Service Bulletin No. DATE: February 23, 2012. Service bulletins Lycoming Engines. As a result of that publication, as representatives of affected NOTE Oils of the type mentioned are to be used in Lycoming aircraft engines for corrosion prevention only, and not for lubrication. com Service Letters and Bulletins: www Tags: crankshaft kits, Lycoming AD 2012-19-01, Lycoming Crankshaft AD, Lycoming IO-540 Service Bulletin, Lycoming O540 Service Bulletin, Lycoming SB 566, Lycoming SB 569A, Lycoming SB 569A-1, R44, r44 helicopter, r44 helicopters, Robinson Helicopter Company, Robinson Helicopter News Lycoming's Mandatory Service Bulletin 632. 1­800­ 258­ 3279 (U. Columbia Aircraft Services provides precision aircraft engine overhauls and repairs. 569A, is incorrect. TELEDYNE CONTINENTAL MOTORS P. Service Bulletins Reprint of Precision Airmotive LLC Mandatory Service Bulletin PEX-1 — Hex Plug: A Penn Yan Aero overhauled IO-540-C4D5D engine leaves the factory fully compliant with all FAA Airworthiness Directives and Lycoming Service Bulletins and Letters. Aug 4, 2017 DATE: August 4, 2017 MODELS AFFECTED: (1) Engines with a serial number listed in Table 1 of this Service Bulletin (2) Engines that have Supersedes Service Bulletin No. According to Lycoming; Lycoming has determined that engines and cylinder kits listed in Lycoming Mandatory Service Bulletin No. Service Instruction on Recommended TBO's for Lycoming Engines Index of Lycoming Service Bulletins, Service Letters, and Service Instructions View LYC SI-1042Z Approved Spark Plugs (PDF) Robinson Helicopter Company 2901 Airport Drive Torrance, CA 90505 310-539-0508 www. Select your model of aircraft below to open the Lycoming Engines. When a manufacturer issues a service bulletin, it sends a copy to the record owners of all of the aircraft affected by the service bulletin. AFS-SB1 This Service Bulletin defines the overhaul requirements for carburetors manufactured by AVStar Fuel Systems, Inc. com (2) You must use this service information as applicable to do the actions required by this AD, unless the AD specifies otherwise. The O-320 no dash according to Lycoming is an O-320-A1A but in reality it is an A2A. . 60294-7 - textron lycoming overhaul manual . 1110c ac fuel pumps, replacement Service Bulletin, Letter and Instruction Index Composite Aircraft 2 Blade Lycoming 2G0 Instructions Service Bulletins. Piece Parts & Cross Reference Search For a ful list of available parts and eligibilities please click here: http://superiorairparts. 0025", #2 = . 1110c ac fuel pumps, replacementService Letter No. for Corrosion on Lycoming Engine SB 505 During an Lycoming O-320 E2A engine overhaul, the internal diameter of the crankshaft was found with corrosion and shop engine removed corrosion but the final diameter was over the max permitted limit per SB 505 (1,920 instead of 1,910). Hi. Lycoming has issued a Mandatory Service Bulletin which requires valve housing replacement. 632B, dated August 4, 2017. For the Lycoming O-360-C2D, HO-360, HIO-360, VO-360 and IVO- 360 series engines, compliance is required within the next 10 hours in service after the effective date of this AD or before the engines have accumulated 400 hours in service, whichever occurs later, unless already accomplished. B. (c) Oil Specification. Quality Aircraft Accessories stocks a wide variety of Lycoming fuel pumps. 371 for improved connecting rod assembly. If the manufacturing lot code and Lycoming part number is listed in Table 3 then proceed with Step 7. click to view/download document(s) 262 1 2002-10-18 RFD Service Bulletin SARBE7-25-73 - Examine Sarbe 7 Antenna 263 - - Not Issued 264 1 2002-10-18 Textron Lycoming Service Bulletin No 533A - Recommendations Regarding Accidental Engine Stoppage 265 - - Not Issued 266 - - Not Issued 267 1 2003-02-01 Hartzell Propeller Service Letter HC-SL-61-184 - Propellers - Lubrication Procedures Service Bulletins. 530) Engineering Aspects are FAA Approved SUBJECT: Application of Protective Coating on Crankshaft The following Textron Lycoming four cylinder engines which utilize fixed pitch This was a very nasty service bulletin affecting Lycoming engines of all models that were built, rebuilt, overhauled or repaired during the past two years. FAA Publishes Emergency Lycoming Engine AD comes in the wake of Lycoming mandatory service bulletin SB 632 released last month that outlines the procedures for completing the engine Per LYCOMING Service Bulletin No. Engines that do not incorporate this new connecting rod are restricted to 1000 hours for VO­540 models and 900 hours f or TVO and TIVO­540. or Equivalently Provisioned Engine per TCDS E-274. 626 A. RETROFIT KIT 940164--501 FOR DUKES ACTUATOR PART NUMBERS: 4196--00--1 AND DIRECT Remanufactured or Overhauled Lycoming Aircraft Engines: IO-540 service limit tolerances not used. e. Administrative Publications © 2004-2019 Textron Inc. ’s and mandatory service bulletins compliance. If you have any questions regarding a part number or whether your plane is affected, please call us at 1-877-833-6948 and we will put you in touch with one of our knowledgeable mechanics. service bulletins, and parts catalogs. 367F and in Supplement No. 505A December 1, 1997 MODELS AFFECTED The following Textron Lycoming four cylinder engines which utilize fixed pitch Aug 3, 2017 Lycoming issued Mandatory Service Bulletin No. 717/323-6181. Service Bulletin Detailing Mandatory Replacement Parts at Overhaul, Repair, Index of Lycoming Service Bulletins, Service Letters, and Service Instructions. ” Lycoming SERVICE 652 Oliver Street INSTRUCTION Williamsport, PA 17701 U. 388C required exhaust valve guide cleaning every 300 hours for helicopter engines and every 400 hours for all other engines. Service Bulletins (published since April 1960) describe mandatory procedures that must be observed for safety reasons, and readily identified by the mandatory heading printed in red. com/SuperiorEligibilities/Bell Aircraft Corporation Model P-39 to P-63 Aircraft Blueprints Engineering Drawings - on DVDs Lockheed F / RF / TF-104 G C Aircraft Operating Data Manual, 250 pages All builders and operators of any model of a Van's Aircraft kit aircraft except RV-12EIS-41000T Twin Engine Aircraft; Lycoming 4cyl Engines, Standard Rotation $3,570. Service information and documentation is provided for each of the aircraft Hangar: 2178 Taxiway F Unit H Minden Tahoe Airport, NV Office and Mailing Address: PO Box 1233 Genoa, NV 89411 Cell Phone: 352-250-5644 jimlee@phoenixairusa. 0034, #3 = . Continental Engine Operation Break-In Service Bulletin Engine operation after cylinder replacement and/or major overhaul. See the latest revision of Lycoming Service Instruction No. a service bulletin may be triggered by the occurrence of a particular event (e. 318 for recommended Page 135 SECTION 7 LYCOMING OPERATOR’S MANUAL INSTALLATION AND STORAGE O-360 AND ASSOCIATED MODELS SERVICE INFORMATION LETTER ---STARTERS--- Page 1 of 1 14900 40th AVE NE • Marysville, Washington 98271 • USA • Tel (360) 651-6666 • Fax (360) 651-6677 LSI-001 REV C PM SERIES STARTERS SUBJECT: STARTER DRIVE LUBRICATION. Textron Lycoming O-320-E2D engines modified by STC SE3692SW and O-320-E3D engines modified by STC SE8987SW must comply with the requirements of AD 98-02-08 (attached). Privacy Policy; Terms & Conditions; Legal; CA Transparency in Supply Chains Act From time to time, Piper Aircraft issues Service Letters, Service Bulletins, or Change Notices in order to address potential issues on aircraft. Campus Store; Choir; Class Attendance; Service Animal Policy (update coming soon) Lycoming College. Those engines involved with this SB will require removal and crankshaft replacement at Lycoming’s expense. 1 thru 112, 114 thru 177, 179 thru 182, also: 184 ­ Modification of Reduction Gear Housing and Associated Parts 185 ­ Modification of Model MA-4SPA Carburetors 186 ­ Approved Generator and Voltage Regulator Combinations (See S. Contact New Parts Sales at 001 (937) 778-4201 (option 1) or e-mail newpartssales@hartzellprop. The first time was at 103. manufacturer's manuals, service bulletins and instruction books regarding the repair and overhaul, inspection, installation, and maintenance of aircraft engines, for that particular make, model and type of engine. 505A December 1, 1997 MODELS AFFECTED The following Textron Lycoming four cylinder engines which utilize fixed pitch Aug 3, 2017 Lycoming issued Mandatory Service Bulletin No. Distribution of Textron Lycoming PA-24-260 Service Lycoming Service Instruction 1037 S (SI1037S) Download Service Instruction No. ohio. 632A July 23 after receiving “isolated reports of connecting rod failures” resulting from a 7 Jan 2019 INDEX OF SERVICE BULLETINS, LETTERS AND INSTRUCTIONS repetitive Exhaust System Inspections per Table 2 in this Service Bulletin. AVStar Flow Divider (Lycoming Fuel 20 Jul 2017 Lycoming has issued Mandatory Service Bulletin 632 that requires owners to check their engines for connecting rods that contain bushings that Jan 7, 2019 INDEX OF SERVICE BULLETINS, LETTERS AND INSTRUCTIONS repetitive Exhaust System Inspections per Table 2 in this Service Bulletin. No. 1009. View Bulletin. However, their publication of S. 6513 CRANKSHAFT REPAIRS (cont. 1037S (SI1037) Lycoming Service Bulletin 533C (SB533) January 27th, 2017 Instructions. They are utilized to disseminate information of a general nature Marc Cook reports on the process of developing a new Lycoming O-233 engine package for the Kitfox Series 7 Super Sport and samples the result. 19 Special Service Publication No. These engines have a different power rating than the more common O-235 L engines. 552 or Service Bulletin No. 1 24/10/1974 notification of avco lycoming service CESSNA RESTART AIRCRAFT SERVICE BULLETIN SUMMARY As of 7-5-04 Mandatory compliance unless stated otherwise Notice - All bulletins: parts and labor credit expires on date published in bulletin or end of two year aircraft warranty, which ever is later. robinsonheli. by David A. CH31921-07-001: CH31921 Igniter: 3/07 : T. Toggle navigation Lycoming Service Instruction #1442: 03/91 : Tornado Alley Turbo Service Bulletin (TAT SB11-05) Service Bulletin 388B, or some variation thereof, is the only way an operator can know for certain if his aircraft is being adversely affected by insufficient oil flow. This site also has Factory issued Service Bulletins, pictures of Great Lakes in flight, maintenance information, airplanes for sale, and links to Great Lakes owners, and a Yahoo chat group. The engines are assembled by certified, highly experienced teams with all critical stages double or triple checked and signed-off. Welcome to Airwolf Filter Corp. * In-Service Date (Lycoming will never sell or rent your information to a third party vendor, and you can opt out of Lycoming crankshafts with a crankshaft serial number listed in Table 4 shipped as a spare after March 1, 1999. - Aviation Software for Regulatory, Maintenance Tracking and Inventory Control. 7. Click here for the Diesel Engines service bulletins. 700 College Place Williamsport, notification of avco lycoming service bulletin no. 1014. Lycoming Service Bulletin 388C addresses this issue by requiring an inspection of exhaust valves and guides every 1000 operating hours. g. Download PDF Service Letters, Bulletins, and Memoranda for the “classic” vintage aircraft supported by Univair. Lombardo of Service Bulletin No. 9. 529 AirworthinessDirective 98-14-03 Amendment 39-1 0637 LYCOMING FUEL PUMPS Proven to be a trouble-free mechanical pressure pump. 574A (or latest revision) may have a cross-threaded cylinder stud hole. Engine disassembled, all parts remain together, no interchanging with other engines. Lycoming Service Bulletins, Service Letters & Service Instructions Index. The information contained in these service bulletins and service instructions is an integral part of, and is to be used in conjunction with, the information contained in this overhaul manual. 501B (Supersedes Service Bulletin No. Christen Eagle Aircraft published Service Bulletins regarding the upkeep and safety services of the aircraft. The same passion, sweat and precision that go into the manufacturing of each Mooney aircraft also power Aircraft Technical Publishers (ATP) is the aviation industry's premier provider of information tools and services for manufacturers, operators/owners, and maintenance Lycoming Engines is an Operating Division of Avco Corporation. For Service Documents associated with Continental ® Motors PMA and experimental engine parts, click here. com . Service Bulletin No. Service Problem Overview LOP Informational Bulletin engineering analyses in an effort to determine the root cause of service failures of Lycoming crankshafts Service Bulletin to make sure you have a complete understanding of the requirements. Lycoming SB240W Mandatory Replacement Parts Prop Strike Lycoming Engine All Mandatory Service Bulletins (MSB) and Engine Warranty Registration. Dynofocal. EQUIPMENT Service Bulletins (sorted by ATA Chapter/SB Number) SB No. lycoming service bulletins This Service Bulletin is in response to field reports of exhaust leaks due to cracked welds and exhaust studs pulling from a cylinder on some Lycoming model TIO-540-AJ1A engines. Select your model of aircraft below to open the OVERHAUL MANUAL-AVCOLYCOMING DIRECT DRIVE AIRCRACT ENGINES Section 1 SECTION i. (Supersedes Service Bulletin No. 632A Dear Mr. 425C Textron Lycoming Service Bulletin No. Disassembly report made. The Service Bulletin and Service Letter Index is split by publication type (i. LIST OF INACTIVE LYCOMING SERVICE BULLETINS, LETTERS AND INSTRUCTIONS INACTIVE SERVICE BULLETINS: No. Instruction 1014. Service Instruction No. alphabetical listing of textron lycoming service bulletins, letters and instructions pub. PA-28,, etc) with similar model series grouped together (see Table of Contents). Lycoming Engines is an Operating Division of Avco Corporation. vansaircraft. Lycoming Engines - Basic Engine Compression Inspection pressure and the appropriate service information should be referenced for this criteria. 3 TTE. 1154 Lycoming Mandatory Service Bulletin No. (2) You must use this service information as applicable to do the actions required by this AD, unless the AD specifies otherwise. 1435. 2 refer to Lycoming Service Instruction No. 1110c ac fuel pumps, replacement13. e, pre-formatted aircraft templates (now counting 400) and an extensive collection of Service Bulletins, IApproach is the "must-have" research software subscription. Delisio, On July 23, 2017, Lycoming published a Mandatory Service Bulletin No. 717/323-6181 TEXTRON LYCOMING - SERVICE BULLETINS, INSTRUCTIONS AND LETTERS Subject: Continental & Lycoming . 18 Jan 11, 2019 Service Instruction No. Exhaust ports serviced. Instruction No. Robinson Helicopter Company 2901 Airport Drive Torrance, CA 90505 310-539-0508 www. Service Bulletins 01. Tel. 18 11 Oct 2018 Cylinder and Head Assembly Serviceable Life DATE: October 11, 2018 SUBJECT: Cylinder and Head Assembly Serviceable Life MODELS Supersedes Service Bulletin No. Textron Lycoming Service Instruction No 1042 in Table 1 of this revision of the Service Bulletin No. Aviation Accident Prevention Bulletins are green bordered and published on an as needed basis. Lycoming issued Mandatory Service Bulletin No. The Lycoming O-320 is a large family of 92 different naturally Multiple service bulletins and airworthiness directives have been issued regarding this Lycoming Engines is the premier aviation engine company recognized for our products, innovation and customer service. We are completing the design on a completely new exhaust system that incorporates a new material. It is dated September 2001, so it may not be up to date. 1435 authorizes the use of a flexiblehose in place of the existing stainless steel tube assembly for the propeller governor oil line on engines with rear mounted governors. 0 SMOH, 566 Since Factory Overhaul, 2964. CH31858-2-07-002-R1A superior airplane deserves superior service & support. Enhanced Gross Weight Taildragger Engine: Lycoming (2000hr. 4 Aug 2017 DATE: August 4, 2017 MODELS AFFECTED: (1) Engines with a serial number listed in Table 1 of this Service Bulletin (2) Engines that have 20 Dec 2017 Service Bulletin No. Engineering Aspects are. The story of Lycoming Engines is a very long and extraordinarily interesting one that includes sewing machines and a bit of mystery as well. 293B and S. Browse our selection of Lycoming fuel pumps below. Add to Wishlist. 00 Propeller flange repair 225. All gears This gear, and the 5/16-24 bolt that secures it to the crankshaft aft end, is the subject of several FAA Airworthiness Directives (AD 2004-05-24 and 2004-10-14) and Lycoming Service Bulletins/Instructions (SBs 475C and 554, SI 1331). Lycoming has reportedly said that it would pay for the service on the engines with under-warranty factory new engines and factory overhauled engines that are addressed by the service bulletin. 487 “Fuel Pump chapter of the Maintenance. Lycoming Service Bulletins. Advise Owners of Lycoming Service Bulletin No. Engine and Cylinder Break-In Instructions. 16. The Federal Aviation Administration (FAA) is the National Airworthiness Authority SERVICE BULLETIN PIPER - Free ebook download as PDF File (. Failure of Weld Repaired Crankcases AWB 85-015 Issue : 1 Date : 19 April the crankshaft main bearing clearance in accordance with Lycoming Service Bulletin (SB Continental & Lycoming Engine Overhaul. Models Affected: All lycoming new, overhauled, rebuilt, or repaired engines with: Ladies and Gentlemen we have received new guidance from senior leadership concerning compliance with Slick Service Bulletins SB2-08 and SB3-08. 2006 · A recent NTSB ruling brings the question of mandatory sevice bulletins into discussion. AVStar Flow Divider (Lycoming Fuel Manifold) Inspection. Lycoming factory new, rebuilt and overhauled) should proceed directly to the FLIGHT TEST section of this Service Instruction that is applicable to your aircraft. Lycoming put out a "Mandatory" service bulletin No. A Service Bulletin is the equivalent of an AD on a Certified Aircraft. Publications 10. November 28 2006 A lawsuit has been filed and is seeking class action status representing nearly 5000 owners of Lycoming Service Bulletins. 0048, #4 = . (Image provided with Savvy Aviation textron lycoming overhaul manual - Exp Aircraft Services Service Instruction 1154K: FAA approved starters, generators, alternators, regulators and relays 247-252 Service Bulletin 240S: Mandatory replacement of parts at overhaul, repair and maintenance 253-254 Service Instruction 1443E: Approved Slick magnetos on Lycoming engines 255-259 Service Instruction 1014M: Lubricating oil recommendations 260-262 Service Bulletin No. Last updated on 02/18/07 Lycoming is the only official source for information about their products. When taking delivery of a new aircraft, there is another point which must be emphasized. We often find that knowing the stories of the manufacturers we represent helps us to deliver better service to our customers. Posted: 14 February 2011. 1276 Bendix Electrical Components 8/14/03 Service Letter Index AA-1 and AA-5 Series - 8 - SL# DATE TITLE EFFECTIVITY 75-5 1 June 1975 Vendor Service Publication (NARCO All Model AA-1 Service Bulletin PDF-35-2 and AA1A, AA-1B, AA-5 Lycoming Service Bulletins 369A, & AA-5B 385A, Service Letter L-159C and Service Instructions 1230A, 1307 Attached) Champion Aerospace Technical Bulletins. bdg/100/21 bdg/100/43 all iss. Does anyone have a copy of this Lycoming Service bulletin (258 ) that they can post here? I've read a few posts about this bulletin, and don't really know what they're talking about. Of all of the forces that act on the valves to create maintenance problems, perhaps heat is the most destructive. Lycoming Aircraft Engines. In that MSB, it describes what do with with an unpainted crankshaft. 2007 December 19. 82. Explore thousands of digitized documents and photographs from unique collections in libraries across Pennsylvania. Visit the Service Bulletin No. The engine and cylinders shall be inspected as described in Lycoming Mandatory Service Bulletin No. 1 24/10/1974 notification of avco lycoming service bulletin no. EIS-41000IC Lycoming and Continental 4cyl Electronic Ignition Kit $3,570. BACKGROUND: Lycoming produces more piston engines for general aviation manufacturers than any other company in the world. Lycoming Service Instruction No 1014 (U. SB3-08. Information here is only to be use for entertainment purposes. AD System with graphics and Service Bulletins Lycoming Service Bulletins SB632 , SB632A and SB632B Connecting Rod Identification DataBases are updated daily. (771 kg)All builders and operators of any model of a Van's Aircraft kit aircraft except RV-12The Lycoming O-320 is a large family of 92 different naturally aspirated, air-cooled, four-cylinder, direct-drive engines commonly used on light aircraft such as the Tdata, Inc. 300) And Propeller Blades, Inspection Of (Per Hartzell Service Bulletin No. • Table 1. 11. This Service Bulletin contains required action 1) to identify connecting rods that contain bushings that do not meet Lycoming Engine’s specifications and 2) any applicable follow-up corrective action. AVStar Fuel Systems, Inc. O. 632 Frequently Asked Questions Lycoming has issued an important Mandatory Service Bulletin that affects a number of (L)O-360, (L)IO-360 and AEIO-360 as well as O-540, IO-540, AEIO-540 and TIO-540 engines. 19 Special Service Publication No. 652 Oliver Street Service Instruction to make sure you have a complete understanding of the requirements. ) Continental Service Bulletins and Repairs Ultrasonic Inspect IAW AD 87-23-08 Included with Grind or Polish 95. 371 may be continued in service to 1200 hours. 301 and Lycoming Service. NOTE . 262 1 2002-10-18 RFD Service Bulletin SARBE7-25-73 - Examine Sarbe 7 Antenna 263 - - Not Issued 264 1 2002-10-18 Textron Lycoming Service Bulletin No 533A - Recommendations Regarding Accidental Engine Stoppage 265 - - Not Issued 266 - - Not Issued 267 1 2003-02-01 Hartzell Propeller Service Letter HC-SL-61-184 - Propellers - Lubrication Procedures As we reported earlier this week, Lycoming Mandatory Service Bulletin 632 requires owners and operators of all Lycoming engines—regardless of model—to check them for off-spec connecting rod bushings within the next 10 hours of flight. So few actually do it. Lycoming Engines is a division of Avco Corporation. 632A to identify connecting rods with non-conforming small end bushings. Authorized Full Service Master Lycoming Distributor. Online Resource - Resources for Mechanics. 632A July 23 after receiving “isolated reports of connecting rod failures” resulting from a bushing becoming unseated from the small end of the connecting rod. 240W. Service Bulletin #MB-2026 Date: March 1, 2002 Airflow Performance Auxiliary Airbox Retention Service Bulletin 1-29-15; Lycoming Flyer - Operations The Glasair Aircraft Owners Association is the one must Inspection of Crankshaft I. Industry’s best service and prices. Eagle Owner information regarding their aircraft. 0069. 5 / 5. 524 Textron Lycoming Service Bulletin No. NO. A Penn Yan Aero overhauled AEIO-360-A1A engine leaves the factory fully compliant with all FAA Airworthiness Directives and Lycoming Service Bulletins and Letters. Lycoming O-320 Series Engines . LYCOMING O-360 Engine Installation SECTION 3 Fuel Lines FUEL FITTINGS ON THE CARBURETOR AND MECHANICAL FUEL PUMP, LYCOMING O-360 SECTION 3 - Page 2 of 11 Parts for Lycoming Engines; Warranty; Service Bulletins. (Refer to latest edition of Textron Lycoming Operator's. Service Instructions 01. of Lycoming engines. You may have to register before you can post: click the register link above to proceed. 50lA) Engineering Aspects are FAA Approved Recall of Piston Pi Part No. Did You Know? Publication number M-0, Standard Practice Maintenance Manual for Spark Ignited Engines is now available. lycoming. The bushings were manufactured between November 2015 to February 2017. This is a list of the variants of the Lycoming O-360 aircraft engine. Manual lists all SBs, SLs. That’s something to be very proud of. Recommended Action for Sudden Engine Stoppage, Propeller/Rotor Strike or Loss of Propeller/Rotor Blade or Tip. Am posting this link for those who may not have all of this information. 25 October 2018 . Publications. of Lycoming engines; bulletins, letters and instructions are issued as required to inform all Service Bulletins (published since April 1960) describe mandatory Aug 4, 2017 DATE: August 4, 2017 MODELS AFFECTED: (1) Engines with a serial number listed in Table 1 of this Service Bulletin (2) Engines that have Supersedes Service Bulletin No. 367f - inspection of engine piston pins withdrawn 31/03/2007 bdg/100/44 all iss. SSP-112-7. service bulletins, instructions and letters Although the information contained in this parts catalog is up-to-date at time of publication, users are advised to procure current information through all Textron Lycoming distributors or from the factory by subscription. " Lycoming MANDATORY Reciprocating Engine Divisionl Subsidiary of Textron Inc. Supplement No. www. Lycoming Tio 540 Maintenance Manual Lycoming has issued Service Bulletin. Date Rev No *Class Chapter Description Effectivity ATA Chapter 07 Lifting and Shoring SB 2742 Feb 1997 - M 07-10 Lifting and Shoring - Bonding of the Wing Jack Pad Assembly BEECHCRAFT Beechjet 400A, Serials RK-114 through RK-133 11/4/2008 Page 4 of 188 Beechcraft Service Bulletin Master Cessna has recently added online access to Service Bulletins and Letters for all Citation models at its support Web site Cessna Provides Service Bulletins and Letters Online. 533A Textron Lycoming must take the position that in the case of a sudden engine stoppage, propeller/rotor strike or loss of propeller/rotor blade or tip, the safest procedure is to remove and disassemble the engine (d) This AD results from Lycoming Engines discovering that the March 1, 1997 start date of affected engine models in Mandatory Service Bulletin (MSB) No. Service Bulletins (SB) are notices to aircraft operators from a manufacturer notifying them of a product improvement. (1) Engines with a serial number listed in Table 1 of this Service Bulletin (2) Engines that have been overhauled or repaired that could contain connecting rod assemblies or connecting rod bushings shipped from Lycoming during dates identified in Table 2 of this Service Bulletin Service Bulletins, Letters and Instructions are available to all from authorized Textron Lycoming distributors, or from the factory; the latest edition of Service Letter No. Lycoming offers Model 114 Service Information Index (Cont) Subject Airworthiness Directive 95-07-01 Textron Lycoming Service Bulletin No. 574A (or latest revision). Recently, Textron Lycoming revised the time interval for certain cylinders to every 1000 hours of operation instead of every 400 hours of operation. is a family owned Transport Canada/EASA approved engine shop established in Canada since 1980. Customers who purchased Lycoming LW-13923 Connecting Rod Bushings not installed in a Connecting Rod from Aircraft Specialties Services, Inc. Bulletin Boards; C. 1 24/10/1974 notification of avco lycoming service In my search for a specific Lycoming Service Bulletin, I came across this list of older Lycoming Service Bulletins, Letters, and Instructions. Lycoming Mandatory Service Bulletin 359 relates only to Lycoming O-235 F and O-235 G engines. Lycoming At Overhaul 100% Parts & Replacement List * Engine Model: O-360-A SERIES, B2D, & C SERIES, D SERIES Description Part Number Quantity Engine Gasket Set SL75439-1 1 Piston Rings SL3601-SC 4 Piston Pins SL13444-1 4 Piston Pin Plugs Inc W/ Pin Exhaust Valves SL19001A 4 Intake Guides SL61681A 4 Exhaust Guides SL74230A 4 Service Bulletins. LW-14077 MODELS AFFECTED. These crankshafts may be installed in any of the engine models listed above. Mon, 04 Feb 2019 11:01:00 GMT Lycoming T53 - Wikipedia - ALPHABETICAL LISTING OF TEXTRON LYCOMING SERVICE BULLETINS, LETTERS AND INSTRUCTIONS PUB. 1094D (a) Cylinder head temperature-maximum limit listed in the Textron Lycoming operator's manual. “Lycoming and Cessna are currently working on a terminating resolution for the Service Bulletin, and hopefully the AD. 240V February 23, 2012 MODELS AFFECTED All Lycoming reciprocating aircraft engines TIME OF COMPLIANCE As specified 18 Oct 2016 Service Bulletin No. Service Bulletins. Since 1812. 1­570­ 323­ 6181 (International) Fax. Mandatory Service Bulletin (SB) No. Lycoming Service Instruction Si 1009 Read/Download Lycoming issued a mandatory service bulletin "Identification of Connecting Rods with Non-Conforming Small End Bushings" today that affects approximately 1300 engines, ranging from O-235 to IO-720 models. Each link points to a PDF file, ranging in size from 75k to over 3MB. 00 Impulse Coupled Magneto Replacement. 388B, mentioned previously, are concrete proof that Lycoming was unable to solve this problem and simply passed it on to the engine owner via these two repetitive, mandatory service bulletins. Time of compliance is within the next 10 hours of engine operation. 2. 318 for recommended lubricating oil. TBO) I0-540-W1A5, 235 HP Fuel Injected Gross Weight: 2800 lbs. alphabetical listing of textron lycoming service bulletins, letters and instructions pub. Effective immediately Maintenance Officers shall comply with Lycoming Service Bulletin 388C concurrent with 100 hr/annual inspections closest to 1,000 hours operating time. 301B. 527C Textron Lycoming Service Bulletin KO. SERVICE BULLETIN 652 Oliver Street Williamsport,PA 17701 U. A Service Letter is either a suggested change, or designed as an assistance to the owner for an area where multiple difficulties arise. 574 6. If you have questions about AD 2017-16-11 or corresponding SB 632, Lycoming has set up a Frequently Asked Questions Page: Service Bulletin No. This AD schedule is applicable to Lycoming O-320 series engines manufactured under FAA Type Certificate Number E-274. SSP-112-8. The EIS-41000IC Electronic Ignition Kit is a fully STC'd kit for most Lycoming and Continental 4cyl engines. 533 C. REVISION All HIGH PRESSURE AC / Lycoming diaphragm type fuel pumps serviced or SERVICE BULLETINS, INSTRUCTIONS AND LETTERS Although the information contained in this manual is up-to-date at time of publication, users are urged to keep abreast of later information through Avco Lycoming Service Bulletins, Instructions and Service Let-ters which are available from all Avco Lycoming distributors or from the Lycoming Engines is the premier aviation engine company recognized for our products, innovation and customer service. The company has even created a tool for the purpose of the testing. You’ll be amazed by what you find!Univair Aircraft Corporation is an American manufacturer specializing in making FAA approved new parts for vintage aircraft such as Piper, Cessna, Ercoupe, Stinson Klaus Savier's Light Speed Engineering Aviation Information PagePanther Takes Flight – Tim Benham from Enid, OK. com Help with Lycoming Service Bulletin Originally Posted by WLIU There is a Lyco SB that describes removing the valve covers, pulling the pushrods out, collapsing the hydraulic valve lifters and measuring the cam lift with a dial gauge. Add To Cart. 77. We build an average of 175 engines per year (Lycoming and Continental) and we work on an array of accessories. 240V February 23, 2012 MODELS AFFECTED All Lycoming reciprocating aircraft engines TIME OF COMPLIANCE As specified Supersedes Service Bulletin No. 298 PA-24-180/250 05/15/64 ** 7200 14E17 426 Propeller Flange Inspection, PA-30 06/26/64 6110 14E22 Crankshaft (Per Lycoming Service Bulletin No. Service Bulletins, Letters and Instructions are available to all from authorized Lycoming distributors, or from the Service Bulletin No. Airworthiness Directive Schedule . 25 SMOH about a year ago, and at that time he had the following exhaust guide wear, #1 = . View Lycoming Recommended TBO Periods (1009AU) All parts meet new limit tolerances - service limit tolerances not used. i. 612, dated 5 April 2016, that requires replacing dipstick P/N LW-16783-18 with PN LW-14760 as the original dipstick "incorrectly gives higher oil level indication when the oil level is actually less than 5 quarts (5 liters). B. time we complied with Lycoming Service Bulletin 388B, and it's supplements on Ed's aircraft. lycoming. 2 What is an aircraft owner or maintenance provider to Search for the latest Delco Delco technical service bulletins here. Original equipment on numerous airframe installations and adaptable to most applications with one of three dual diaphragm types. The Federal Aviation Administration (FAA) is the National Airworthiness Authority SLICK Service Bulletin SB1-12 ISSUED MO DAY YR 09 06 12 CHAMPION PROPRIETARY INFORMATION - Subject to the restrictions on the cover or first page If the magneto is functioning correctly and is within the Champion 1-year, 500 hour time-in-service warranty period, the magneto may be returned to Champion for rework and returned at no-charge. (ii) Reserved. Textron Lycoming Break-in Instructions Service instruction No. 19 of Lycoming engines; bulletins, letters and instructions are issued as required to inform all Service Bulletins (published since April 1960) describe mandatory Special Service Publication No. So many people dream it. Loading Loading abnormal metal content, additional service may be required to determine the source and possible need for corrective maintenance. Some aircraft manufacturers add Aviat Aircraft Pitts published Service Bulletins regarding the upkeep and safety services of the aircraft. All Lycoming turbocharged engines must be broken in with ash-less dispersant oil only. Ideally, a newly overhauled aircraft engine should be tested in a test cell where operating conditions can Service Bulletin No. - Aviation Software for Regulatory, Maintenance Tracking and Inventory ControlConversion of 7ECA, 7GCAA and 7GCBC to Lycoming O-320-B2B. 621A (Supersedes Service Bulletins No. the rebuilding procedure to insure that A. While there have been no failures in the crankshafts which are the subject of this Service Bulletin, as part of our commitment to quality, Lycoming is Lycoming has issued Mandatory Service Bulletin 632 that requires owners to check their engines for connecting rods that contain bushings that do not meet Lycoming Engine’s specifications within the next 10 hours of operation. All Rights Reserved. Aero Atelier CM, Inc. A propeller strike is defined as follows: SERVICE BULLETIN INDEX - November 01, 2018 (excluding HD series propeller and systems) HC-12X20-8C/8433-6 installed on the Lycoming O-435 engines (Bellanca). Lycoming has what I consider to be one of the best Service Bulletins out there regarding oil and filter change and screen cleaning. The TSB summary will display the defective part and the manufacturers involved. Lycoming just released Mandatory Service Bulletin No. SERVICE. SERVICE BULLETINS, INSTRUCTIONS, AND LETTERS Although the information contained in this manual is up-to-date at time of publication, users are urged to keep abreast of later information through Lycoming Service Bulletins, Instructions and Service Letters which are available from all Lycoming distributors or from the factory by subscription. This supplement for Service Instruction No. gal/lt). According to the SB, the bushings were shipped from the factory between Nov. Lycoming reciprocating aircraft engines with a serial number listed in Table 1 of Lycoming Service Bulletin (SB) No. 1014 and latest revision of Service Bulletin No. DATE: May 2, 1995 Service Bulletin No. 31. Carefully unfold the paper element and examine the material trapped in the filter. These incidents Lycoming Service Bulletin No. D. in Lycoming Service Instruction No. through Avco Lycoming Service Bulletins, Instructions and Service Letters lubricating oils recommended in the latest edition of Service. These notices are provided here for dealers and owners. Lycoming Mandatory Service Bulletin No. lycoming service bulletinsJan 7, 2019 INDEX OF SERVICE BULLETINS, LETTERS AND INSTRUCTIONS repetitive Exhaust System Inspections per Table 2 in this Service Bulletin. DESCRIPTION DATE; 2007: T. 00 Lycoming Service Bulletins and Repairs The move comes days after the manufacturer published its Mandatory Service Bulletin 632 . Special Airworthiness Information Bulletins (SAIB) Share on Facebook; Tweet on Twitter; A Special Airworthiness Information Bulletin (SAIB) is an information tool that alerts, educates, and makes recommendations to the aviation community. In the field we call this, "Valve wobble test". 262 1 2002-10-18 RFD Service Bulletin SARBE7-25-73 - Examine Sarbe 7 Antenna 263 - - Not Issued 264 1 2002-10-18 Textron Lycoming Service Bulletin No 533A - Recommendations Regarding Accidental Engine Stoppage 265 - - Not Issued 266 - - Not Issued 267 1 2003-02-01 Hartzell Propeller Service Letter HC-SL-61-184 - Propellers - Lubrication Procedures Lycoming O-320-H2AD. T/206H 3-01-04 notification of avco lycoming service bulletin no. If engine employs a pressure screen system, check the screen for metal particles. Congratulations - you’re building your own airplane. With all new speed enhancements in IApproach version 6. 77611 LYCOMING GASKET - EXHAUST FLANGE $9. Ideally, a newly overhauled aircraft engine should be tested in a test cell where operating conditions can Textron Lycoming Service Instruction 1014 should be consulted for this information. 527C, dated April 18, 1997, that adds additional affected engine models and lists serial numbers (S/Ns) of additional engines manufactured, remanufactured, or overhauled by Textron Lycoming during the time period that defective service table of limits This Table of Limits is provided to serve as a guide to all service and maintenance personnel engaged in the repair and overhaul of Textron Lycoming Aircraft Engines. Lycoming O-320 Series. Ignition - Transmittal of Continental Motors Service Bulletin SB15-5 and Lycoming Service Letter No. Failure of a connecting rod can lead to an uncommanded complete loss of engine power, Lycoming said. Pressure Screen. A. L264A : Cessna Service Document Change Notification 14401 Keil Road NE, Aurora, Oregon, USA 97002 PHONE 503-678-6545 FAX 503-678-6560 www. 00 Ultrasonic Inspection Only 150. after November 18, 2015 the Mandatory Service Bulletin 632B may apply based on the limited information provided by Lycoming. 373 withdrawn. In the Experimental Regulations, no channel exists for AD's, as such we call them Service Bulletins. A buddy has an early Apache, same engine, O-320 with no dash number, controllable props. Within these series, applicable service bulletins/letters are listed in numerical order. To search these publications, please click here. 569 SIM20-112A. kits and intake valves and inspection instructions to identify the suspect intake valves. 1, 1997, within the compliance times specified by AD 98-02-08. The Service Bulletin is available on the Lycoming website at www. See latest revision of Service Bulletin No. service bulletins, instructions and letters Although the information contained in this parts catalog is up-to-date at time of publication, users are urged to keep abreast of later information through all Lycoming distributors or from the factory by subscription. Perform crankshaft inspections per Textron Lycoming Service Bulletin No. Maintenance Manual required, adjust per Lycoming Service Instruction 1042). 486 Labor costs can be recovered by submitting a warranty application through any authorized Textron Lycoming Distributor. click to view/download document(s) Service bulletins letters and instructions, alphabetical listing of textron lycoming service bulletins, letters and instructions pub no title si 1276 bendix electrical components bulletin no 529a, “torque values for drive shaft nut”. Service Bulletins; Service Letters List of Service Bulletins MT-Propeller –B Flange installation Hardware Inspection on Lycoming Engines using SAE No. 240V February 23, 2012 MODELS AFFECTED All Lycoming reciprocating aircraft engines TIME OF COMPLIANCE As specified Supersedes Service Bulletin No. Service Instruction to make sure you have a complete understanding of the requiremen ts. 09. New, rebuilt, overhauled Lycoming O-320 engines for sale. Lycoming series engines and all engines overhauled by Lycoming (also known as remanufactured) listed below and in Lycoming Service Bulletin No. SERVICE BULLETIN TM excellence ISSUED REVISED MO DAY YR MO DAY YR PAGE No. As a result of these early inspection Lycoming Mandatory Service Bulletin No. LYCOMING OPERATOR’S MANUAL SECTION 5 that personnel be familiar with latest revision of Service Instruction No. Service bulletins MT-Propeller - The Winners' Propeller - High Performance Propellers for Aircraft, Hovercraft and WindtunnelsEngine disassembled, all parts remain together, no interchanging with other engines. You can find the Service Bulletins for Continental ® Motors Type Certificated Gasoline Engines below. Service Bulletins, Instructions and Letters By far the most important “do” I can tell you is to read and follow our library of service bulletins, service instructions and service letters, the latest of which are available at www. RE: Lycoming Service Bulletin No. This Service Instruction identifies approved fuels that can be used when refueling aircraft with Lycoming engines. 1 Service Bulletin No. SB 480E or its latest revision should be religiously followed by all to ensure your engine is properly maintained. 425 Lycoming Service Bulletin No. Continenal Motors Service Bulletins. org Title __ A Textron Company 852 Oliver Street All Lycoming wide cylinder flange engines identified by the suffix "A" or "E" Refer to the latest revision of Service TELEDYNE CONTINENTAL ® IGNITION SYSTEMS MANDATORY SERVICE BULLETIN Lycoming, Franklin and other logbook entry indicating compliance with the inspection Composite Aircraft 2 Blade Lycoming 2G0 Instructions Service Bulletins. Dec 7, 1974 - Service Bulletins, Service Instructions and Service Letters are available from all Textron Ly- Lycoming factory new, rebuilt and overhauled) should proceed directly to the FLIGHT TEST section of this Service Instruction that is applicable to your aircraft. 18, 2015, and Nov. Lycoming Spec. 8/14/03 Service Letter Index AA-1 and AA-5 Series - 8 - SL# DATE TITLE EFFECTIVITY 75-5 1 June 1975 Vendor Service Publication (NARCO All Model AA-1 Service Bulletin PDF-35-2 and AA1A, AA-1B, AA-5 Lycoming Service Bulletins 369A, & AA-5B 385A, Service Letter L-159C and Service Instructions 1230A, 1307 Attached) The Lycoming Mandatory Service Bulletin SB505B does apply (it says all 320 series engines). (1270 kg) Empty Weight: 1700 lbs. 569A Lycoming has continued to analyze crankshafts in service. April 24, 1990. Service Bulletins . Compression testing will only reveal the problem late in its development, if at all. Notes: 1. and Canada) Tel. Airwolf is the world’s largest manufacturer of remote mount oil filter systems, air/oil separators and wet vacuum pumps. 533A. The basic rule which applies to most normally aspirated Lycoming piston engines is simple; use straight mineral oil of the proper viscosity for the first fifty hours or until oil consumption stabilizes. Tim Benham from Enid, OK has been flying his Lycoming YAEIO-233 powered Panther and sent this note and photos over. Lycoming College. txt) or read book online for free. L171. 505B , dated Dec. Lycmoming has been producing aircraft engines since 1929 and is actively involved in certifying their engines to run on mogas and possibly other fuels as avgas will be phased out within the next couple of years. Lycoming Aircraft Engine Parts. L114 describes the subscription policy regarding these publications. Lycoming Service Bulletin, Service Letter n Service Instruction. Now you can order Continental ® Motors parts, Continental ® Motors FAA approved parts for Lycoming ® * engines and Titan experimental engine parts easier than ever. Notes, Bulletins And Service Instructions are in compliance. This link goes to the Lycoming powerplant products page. 624 and 626. Pitts Owner information regarding the aircraft. Service bulletins, service instructions and se rvice for the major overhaul of the Avco Lycoming horizon- letters are issued from time totimd whenever the en- tally installed direct drive engines. Only difference is the plug in the crank which is easily installed or removed and the hole in the aft plug. There are 167 different models within the O-360 family of engines, with 12 different prefixes. Service bulletins are posted as a courtesy to our customers. Manual prior to installing new pump BeLogistics | Best WordPress theme for logicstick companies. Service Bulletins for propellers. If you can't find the Lycoming fuel pump you need, contact us with your Lycoming fuel pump request. The following definition of PROPELLER STRIKE is taken from a blending of the requirements stated in Lycoming Service Bulletin SB 533-A, Continental Service Bulletin SB96-11, and AD-2004-10-14. 480E d. [vc_row][vc_column][vc_column_text]This area contains useful information regarding warranties, instructions, and other documents. Textron Lycoming encourages the use of spectrograph oil analysis to monitor engine component wear rates. S. Lycoming reciprocating aircraft engines repaired or overhauled using connecting rod assemblies or connecting rod bushing identified in Table 2 of Lycoming SB No. 526 Textron Lycoming Service Bulletin No. (i) Lycoming Engines Mandatory Service Bulletin No. Lycoming Engines issued Supplement 1 to MSB No. Read the Service bulletin about using this in 61173 LYCOMING OIL SCREEN GASKET $1. pdf), Text File (. 86) 430 Inspection Of Nose Gear PA-30 08/17/64 3220 14F6 Drag Link Assembly Letters, and Service Instructions. Lycoming SERVICE 652 Oliver Street INSTRUCTION Williamsport, PA 17701 U. 1070 regarding specified fuel for Lycoming Lycoming has issued an important Mandatory Service Bulletin that affects a number of (L)O-360, (L)IO-360 and AEIO-360 as well as O-540, IO-540, AEIO-540 and TIO-540 engines. Professionally overhauled in 2010 in accordance with Lycoming Service Bulletin 240U dated May 8, 2009 and the Lycoming Overhaul Manual p/n 60298-4. Publications 01. 518C (Supersedes Service Bulletin No. comIvoprop manufacters, the Ivo prop Ultralight, IVOPROP Medium, Magnum, and airboat propellers. If your engine was overhauled by Penn Yan Aero prior to November 2015, then Lycoming's Mandatory Service Bulletin 632 does not apply. 632B. and that wear is the reason Lycoming went to roller lifters about eight or nine years ago. Over the years, Marvel-Scheblers's predecessors, Volare Carburetors LLC, Precision Airmotive Corporation, Facet Aerospace Products Company, Borg-Warner and Marvel-Schebler ® Carburetor Company, have issued service bulletins, service letters, and other service information in a variety of formats. O-320 Series L-6798-39A thru L-6815-39A IO-320 Series L-4952-55 Issue 100 service bulletin index 2009-07-15 page 1 pc-a-00-00-00-02b-930a-a service bulletin index this index gives a list of all service bulletins for the bn2 Unlimited Aero Engines specializes in the repair of engines involved in sudden stoppage/prop strike incidents. EFFECTIVITY: PM Series Starters installed on Lycoming Engines. com DATE: October 4, 2012 Service Bulletin No. com. 593. 367F. 1. 717/323-6181 TEXTRON LYCOMING - SERVICE BULLETINS, INSTRUCTIONS AND LETTERS Subject: Superior Air Parts - Service Bulletin database; Continental Motors - Service Bulletins